How to Replace an Oldsmobile Aurora Fuel Pump

by Leonardo R. Grabkowski

The Oldsmobile Aurora was sold between 1995 and 2003. A bad fuel pump in your Aurora can keep your engine from receiving fuel or cranking. Replacing a fuel pump is not an easy task and will probably require an hour or two or your time. The Aurora fuel pump is part of the fuel-sending unit assembly, so the entire assembly must be replaced.

Step 1

Remove the gas cap and unhook the negative battery cable. Open the hood, snap off the plastic engine cover (if equipped) and locate the fuel pressure valve on the fuel rail.

Step 2

Connect the fuel pressure gauge to the valve and set the bleed valve inside a sealable container. Relieve the fuel pressure and let the excess fuel drain into the container.

Step 3

Make sure your fuel tank is no more than 1/8 of a tankful. If it's not, you will need to siphon some of the fuel out. Use the siphon pump to drain excess fuel into the same container.

Step 4

Open the trunk and remove the trunk liner and the spare tire and jack. Locate the fuel tank access cover close to the back of the rear seat. Use the screwdriver to remove the screws from the access cover.

Step 5

Unhook the fuel lines and label them for their position on the assembly. Labeling them will ensure you don't get them cross-connected when you are reinstalling them.

Step 6

Unhook the electrical module at the top of the assembly. Have your container nearby for when you remove the assembly; the catch pan will be full of fuel.

Step 7

Use the channel locks to remove the locking ring around the assembly, but be careful. Hold down the assembly as you are removing the locking ring. The assembly is spring-loaded and will abruptly pop up. Hold onto it until the locking ring is removed and let it rise up slowly. Remove the o-ring when you have the assembly out.

Step 8

Clean the mounting area thoroughly with a shop rag. Install the new o-ring and set the new fuel assembly in position by twisting it and pushing down. Carefully replace the locking ring.

Step 9

Reattach the fuel lines as labeled or marked, and then connect the electrical connection. Replace the fuel tank access cover, spare tire and trunk liner.

Step 10

Replace the gas cap and reconnect the negative battery cable. Turn your ignition key on without cranking the vehicle. Keep it on for 3 to 5 seconds, and then turn it off. Repeat this process 2 or 3 times to repressurize your fuel system. The fuel system must be pressurized before starting the engine or it will have trouble cranking.

More Articles

article divider
×