Having a leak around a car rear windshield can be very annoying. If you don't take care of it quickly, your car interior can get soaked during a torrential rainstorm. During a smaller storm, it can get just wet enough to leave a lovely mildew smell and get water spots on the upholstery. That makes it important to fix the leak when you first notice it, before it has a chance to get any worse.
Things You'll Need
- One-gallon jug or garden hose Flathead screwdriver Rough sandpaper Cotton rag Rubbing alcohol Duct tape Polyurethane caulk Caulking gun
Locate the source of the leak. Ask a friend to pour a gallon of water on your rear windshield, moving the jug from left to right across the top, as you sit in the rear seat of the vehicle or in the hatch. As the water runs down the windshield, determine the spot where it starts coming inside the car. If the first gallon doesn't cause a leak, refill the jug and repeat as needed or use the garden hose.
Take your screwdriver and gently pry the rubber window trim away from the windshield near the source of your leak, being careful not to bend or nick it. Check the channel (the metal well underneath the trim) for cracks or rust. Also inspect the bottom of the windshield's glass for nicks, chips or cracks.
Wipe out the channel with a cotton rag dipped in rubbing alcohol so you have a smooth surface to work with. Sand off any rust with 80-grit sandpaper and wipe out any fragments. Fill the channel with polyurethane sealant using your caulking gun, leaving an eighth of an inch of space at the top of the channel to accommodate the trim. Before the caulk has a chance to dry, replace the trim you lifted up. Secure it in place with duct tape. The pressure on the caulk will help stick it back to the window, leaving it lying flat.
Allow the caulk 30 minutes to dry, then remove the tape. Repeat the water test from Step 1 to ensure that you've taken care of the problem. If not, add more caulk and try again.
Tips & Warnings
- Tape plastic sheeting over the entire inside of your windshield, including the channels, to keep your car dry until you have a chance to fix the leak.
- If the problem is a crack in the glass, not a nick or a chip, contact your insurance company. It's a good idea to replace your entire rear windshield since cracks have a bad habit of getting bigger with time.The repair cost is often covered under comprehensive claims.
How to Fix a Power Steering Leak
The power-steering system on your car operates under high pressure, making leaks a common problem. To find and fix a leak, you...
How to Fix an Air Leak in a Car Window
An air leak coming from your car's window can mean one of two things: You have a problem with your window, or...
How to Fix an Automotive Window Seal Leak
A seal leak about the windows of your automobile can be disappointing. But, it happens to many vehicles, especially with age. The...
How to Fix a Leak in a Bay Window
Leaky bay windows can be a big problem for homeowners. Not only can water leak into the house, but it also can...
How to Repair a Leaking Windshield Seal
Leaking windshields are, in most cases, caused by faulty seals around the glass, perhaps created by mildew or other deterioration of the...
How to Know if Your Car Has a Fluid Leak
Except for gasoline and windshield wiper solution, the fluids in your car shouldn't get used up or go anywhere. If you notice...
How do I Find an Air Leak in a Windshield or Side Window of a Car?
Air leaks around windshields or side windows in your car can range from mildly annoying to nearly unbearable. When air slides through...
How to Check for a Windshield Washer Fluid Leak
A clean windshield may be in jeopardy if there's a washer fluid leak. Learn how to check and fill the fluids on...